Club Car Onward 4 Passenger
clubcar.com/en-us/personal/golf-carts/onward-4-passenger
Last updated: 19 September 2026
What we found
- 23 batteries are documented for it, from the manufacturer's own documentation.
- 1 battery is explicitly documented as NOT fitting it: 38V 105Ah Cube LiFePO4 Gen3.
- 12 specifications are published for it, each with the source it was read from.
- 1 recall or safety notice is matched to it.
Assembled from the evidence on this page. Every figure and count below is shown with the source it was read from.
What else the Onward 4 Passenger needs
Parts a source says are needed beyond the battery itself. Reported, not recommended — read the source beside each one and confirm it with the manufacturer before buying anything.
- Vendor statedWhatever pack is fitted
A 12 V DC-DC step-down converter to feed the cart's 12 V accessories — lights, radio, horn — which lose their supply when the lead-acid string they were tapped off becomes a single 48 V module. Epoch include one in their conversion kit; Allied sell one separately, in a collection named for the purpose.
“a 12V DC-DC Converter (to safely power your lights and radio)”
Source: epochbatteries.com/products/48v-105ah-lithium-golf-cart-kit
- Vendor statedWhatever pack is fitted
A FactorySync harness and a matching firmware build, both specific to this cart, on top of the pack itself. Bolt Energy list a harness part number and a firmware code against every cart line in their fitment guide and sell the harness as a separate part: a replacement pack that is electrically right for the cart is still not installable without them. For a Tempo or an Onward there are TWO, and which one is right depends on the pack the cart left the factory with: harness 33-036 with firmware CLUBVG for a Vanguard, harness 33-037 with firmware CLUBLG for an LG Chem.
“33-036 CLUBVG”
Source: boltenergyusa.com/wp-content/uploads/2026/08/Bolt-FactorySync-Fitment-Guide_081026-1.pdf
Motor and performance
- Motor type
- A 30 V AC motor
- Top speed
- 19.2 mph on level ground
- Speed controller rating
- 375 A, AC
“Motor Type 30V AC motor 30V AC motor 30V AC motor 30V AC Motor”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
“High Speed (Level Ground) 19.2 mph 19.2 mph 19.2 mph 19 mph”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
“Speed Controller 375 Amp AC 375 Amp AC 375 Amp AC 375 Amp AC”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
Battery and charging
- What the cart carries from the factory
- Six 8-volt batteries — a 48-volt system
- Charger fitted to the lithium trim
- A Delta-Q, 650 W or 900 W
- Vehicle control module
- A Vehicle Control Module on a CAN bus
- Pack enclosure
- A watertight steel case, stated to IP67
- Battery gauge
- A standard LED gauge
- Dynamic brake resistor
- A 1,000 watt dynamic brake resistor
- Lithium pack, where the maker offers one
- Sources disagree
3.1 kWh base, or 7.0 kWh on the Extended Range
“Batteries 3.1 kWh (Base Li-ION) or 7.0 kWh (XR Li-ION) 3.1 kWh (Base Li-ION) or 7.0 kWh (XR Li-ION) 3.1 kWh (Base Li-ION) or 7.0 kWh (XR Li-ION) 7.0 kWh Lithium-Ion”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
4.0 kWh on the Base, 7.0 kWh on the XR
“Batteries 12-volt (1) 8-volt (6) 4.0 kWh (Base Li-ION) or 7.0 kWh (XR Li-ION)”
Source: clubcar.com/en-us/personal/golf-carts/onward-4-passenger/specifications
- Charger fitted
- E.R.I.C. Automatic 48-volt, UL and CSA listed
“Batteries 12-volt (1) 8-volt (6) 4.0 kWh (Base Li-ION) or 7.0 kWh (XR Li-ION)”
Source: clubcar.com/en-us/personal/golf-carts/onward-4-passenger/specifications
“Battery Charger 650W AC Delta Q 650W AC Delta Q (Onboard Available) 650W AC Delta Q (Onboard Available) 650W AC Delta Q (Onboard Available) 900W AC Delta Q 900W AC Delta Q 900W AC Delta Q 900W AC Delta Q”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
“Vehicle Control Module (VCM): “Brains” of the electronic control system. It features CAN bus communication and controls vehicle inputs and outputs”
Source: clubcar.com/en-us/lithium-ion
“Club Car's lithium ion solution is fully enclosed and self contained in a water tight steel case, meeting IP67 standards.”
Source: clubcar.com/en-us/lithium-ion
“Battery Gauge/ Vehicle Information Display: Standard LED gauge”
Source: clubcar.com/en-us/lithium-ion
“Dynamic Brake Resistor (DBR): 1,000 watt resistor (Tempo and Onward)”
Source: clubcar.com/en-us/lithium-ion
“Battery Charger N/A E.R.I.C. Automatic, 48-volt; UL, CSA listed E.R.I.C. Automatic, 48-volt; UL, CSA listed”
Source: clubcar.com/en-us/personal/golf-carts/onward-4-passenger/specifications
Size and fit
- Curb weight
- 784 lbs, on the base pack
- Load capacity
- 800 lbs
“Curb Weight 717 lbs (Base LI-ION) 727 lbs (XR LI-ION) 784 lbs (Base LI-ION) 794 lbs (XR LI-ION) 905 lbs (Base LI-ION) 915 lbs (XR LI-ION) 1102 lbs”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
“Vehicle Load Capacity 500 lbs 800 lbs 800 lbs 1200 lbs”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
United States — CPSC
Affected product: Club Car Precedent, Tempo, Onward and Villager model gas golf and transport vehicles
This recall covers only some units of this product, identified by specific serial or identification numbers, specific model numbers, specific model years and the dates it was sold. Check the recall notice against your own unit before concluding whether it is affected.
Units covered: This recall involves model year 2019 gas-powered Precedent, Tempo, Onward and Villager golf and transport vehicles, which are used for short-distance transportation. Vehicles with the following model and serial numbers are included in the recall. Serial numbers are located above and to the right of the accelerator pedal. The model number is the first two letters of the serial number. Model Name Model Number Serial Number Tempo Gas BX BX1905-944274 to BX2003-039920 Tempo Gas 2 + 2 BY BY1910-953754 to BY2002-039481 Onward 2 Pass Non-Lifted Gas BQ BQ1924-981193 to BQ2003-041072 Onward 4 Pass Non-Lifted BS BS1910-953760 to BS2003-041012 Onward 4 Pass Lifted Gas BW BW1910-953767 to BW2003-041068 Precedent Villager 2 Gas BJ BJ1910-953915 to BJ2002-039525 Precedent Gas EFI 2P DF DF1929-987941 to DF2002-039479 Precedent Villager 4 Gas DJ DJ1929-987934 to DJ1950-034968 Onward 6 Pass Non-Lifted Gas AY AY1945-024474 to AY1949-033252 Onward 6 Pass Lifted Gas AW AW1945-024474 to AW2003-041004
Hazard: Fuel can leak from an improperly-routed fuel line, posing fire and burn hazards.
Remedy: Consumers should immediately stop using the recalled vehicles and contact Club Car to schedule a free repair. Club Car is contacting owners directly.
Recall date August 19, 2019
View official CPSC recall noticeEuropean Union
We did not match this product to any recall in the data we hold from the European Union, last checked September 19, 2026. Check the European Union’s own search: ec.europa.eu/safety-gate-alerts/screen/search
United Kingdom
We did not match this product to any recall in the data we hold from the United Kingdom, last checked September 19, 2026. Check the United Kingdom’s own search: gov.uk/product-safety-alerts-reports-recalls
Australia
We did not match this product to any recall in the data we hold from Australia, last checked September 14, 2026. Check Australia’s own search: productsafety.gov.au/recalls
Canada
We did not match this product to any recall in the data we hold from Canada, last checked September 19, 2026. Check Canada’s own search: recalls-rappels.canada.ca/en/search
France
We did not match this product to any recall in the data we hold from France, last checked September 19, 2026. Check France’s own search: rappel.conso.gouv.fr
None of these is a statement that the product is safe or unrecalled — only that our searches found nothing. Each regulator’s own search is linked above.