Club Car Onward 2 Passenger
clubcar.com/en-us/personal/golf-carts/onward-2-passenger
The Club Car Onward 2 Passenger is a golf cart with a stated top speed of 19.2 mph on level ground and a load capacity of 500 lbs.
Last updated: 11 October 2026
What we found
- Batteries are documented for it, from the manufacturer's own documentation.
- Further batteries are listed on this model's battery page and are not included in the count above.
- A battery is explicitly documented as NOT fitting it: 38V 105Ah Cube LiFePO4 Gen3.
- Specifications are published for it, each with its source.
- 1 recall or safety notice is matched to it.
- 1 figure is contradicted by another credible source. Both readings are shown below, and neither is presented as the correct one.
What else the Onward 2 Passenger needs
Parts a source says are needed beyond the battery itself. Reported, not recommended — read the source beside each one and confirm it with the manufacturer before buying anything.
- Vendor statedWhatever pack is fitted
A 12 V DC-DC step-down converter to feed the cart's 12 V accessories — lights, radio, horn — which lose their supply when the lead-acid string they were tapped off becomes a single 48 V module. Epoch include one in their conversion kit; Allied sell one separately, in a collection named for the purpose.
“a 12V DC-DC Converter (to safely power your lights and radio)”
Source: epochbatteries.com/products/48v-105ah-lithium-golf-cart-kit
- Vendor statedWhatever pack is fitted
A FactorySync harness and a matching firmware build, both specific to this cart, on top of the pack itself. Bolt Energy list a harness part number and a firmware code against every cart line in their fitment guide and sell the harness as a separate part: a replacement pack that is electrically right for the cart is still not installable without them. For a Tempo or an Onward there are TWO, and which one is right depends on the pack the cart left the factory with: harness 33-036 with firmware CLUBVG for a Vanguard, harness 33-037 with firmware CLUBLG for an LG Chem.
“33-036 CLUBVG”
Source: boltenergyusa.com/wp-content/uploads/2026/08/Bolt-FactorySync-Fitment-Guide_081026-1.pdf
Motor and performance
- Motor type
- A 30 V AC motor
- Top speed
- 19.2 mph on level ground
- Speed controller rating
- 375 A, AC
“Motor Type 30V AC motor 30V AC motor 30V AC motor 30V AC Motor”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
“High Speed (Level Ground) 19.2 mph 19.2 mph 19.2 mph 19 mph”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
“Speed Controller 375 Amp AC 375 Amp AC 375 Amp AC 375 Amp AC”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
Battery and charging
- What the cart carries from the factory
- Six 8-volt batteries
- Battery fitted
- 48V DC with 6 x 8V Flooded Lead Acid Batteries
- Charger fitted to the lithium trim
- A Delta-Q, 650 W or 900 W
- Vehicle control module
- A Vehicle Control Module on a CAN bus
- Pack enclosure
- A watertight steel case, stated to IP67
- Battery gauge
- A standard LED gauge
- Dynamic brake resistor
- A 1,000 watt dynamic brake resistor
- Lithium pack, where the maker offers one
- Sources disagree
4.0 kWh on the Base, 7.0 kWh on the XR
“Batteries 12-volt (1) 8-volt (6) Base Li-Ion: 4.0 kWh XR Li-Ion: 7.0 kWh”
Source: clubcar.com/en-us/personal/golf-carts/onward-2-passenger/specifications
3.1 kWh base, or 7.0 kWh on the Extended Range
“Batteries 3.1 kWh (Base Li-ION) or 7.0 kWh (XR Li-ION) 3.1 kWh (Base Li-ION) or 7.0 kWh (XR Li-ION) 3.1 kWh (Base Li-ION) or 7.0 kWh (XR Li-ION) 7.0 kWh Lithium-Ion”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
- Charger fitted
- E.R.I.C. Automatic 48-volt, UL and CSA listed
“Batteries 12-volt (1) 8-volt (6) Base Li-Ion: 4.0 kWh XR Li-Ion: 7.0 kWh”
Source: clubcar.com/en-us/personal/golf-carts/onward-2-passenger/specifications
“Battery Type 48V DC with 6 x 8V Flooded Lead Acid Batteries”
Source: inventory.bentwrenchcarts.com/listing/used-2023-hp-fla-club-car-onward-linwood-north-carolina-12166
“Battery Charger 650W AC Delta Q 650W AC Delta Q (Onboard Available) 650W AC Delta Q (Onboard Available) 650W AC Delta Q (Onboard Available) 900W AC Delta Q 900W AC Delta Q 900W AC Delta Q 900W AC Delta Q”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
“Vehicle Control Module (VCM): “Brains” of the electronic control system. It features CAN bus communication and controls vehicle inputs and outputs”
Source: clubcar.com/en-us/lithium-ion
“Club Car's lithium ion solution is fully enclosed and self contained in a water tight steel case, meeting IP67 standards.”
Source: clubcar.com/en-us/lithium-ion
“Battery Gauge/ Vehicle Information Display: Standard LED gauge”
Source: clubcar.com/en-us/lithium-ion
“Dynamic Brake Resistor (DBR): 1,000 watt resistor (Tempo and Onward)”
Source: clubcar.com/en-us/lithium-ion
“Battery Charger N/A E.R.I.C. Automatic, 48-volt; UL, CSA listed 650W HF Li-ION Shelf CHarger”
Source: clubcar.com/en-us/personal/golf-carts/onward-2-passenger/specifications
Size and fit
- Curb weight
- 717 lbs, on the base pack
- Load capacity
- 500 lbs
“Curb Weight 717 lbs (Base LI-ION) 727 lbs (XR LI-ION) 784 lbs (Base LI-ION) 794 lbs (XR LI-ION) 905 lbs (Base LI-ION) 915 lbs (XR LI-ION) 1102 lbs”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
“Vehicle Load Capacity 500 lbs 800 lbs 800 lbs 1200 lbs”
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
Recalls and fire safety
- Hazard the regulator describes
- Fuel can leak from an improperly-routed fuel line, posing fire and burn hazards
- Remedy the regulator gives
- Consumers should immediately stop using the recalled vehicles and contact Club Car to schedule a free repair
- Units the recall covers
- model year 2019 gas-powered Precedent, Tempo, Onward and Villager golf and transport vehicles
“Fuel can leak from an improperly-routed fuel line, posing fire and burn hazards.”
Source: cpsc.gov/Recalls/2019/Club-Car-Recalls-Gas-Golf-and-Transport-Vehicles-Due-to-Fire-and-Burn-Hazards-Recall-Alert
“Consumers should immediately stop using the recalled vehicles and contact Club Car to schedule a free repair.”
Source: cpsc.gov/Recalls/2019/Club-Car-Recalls-Gas-Golf-and-Transport-Vehicles-Due-to-Fire-and-Burn-Hazards-Recall-Alert
“This recall involves model year 2019 gas-powered Precedent, Tempo, Onward and Villager golf and transport vehicles, which are used for short-distance transportation.”
Source: cpsc.gov/Recalls/2019/Club-Car-Recalls-Gas-Golf-and-Transport-Vehicles-Due-to-Fire-and-Burn-Hazards-Recall-Alert
Recalls (1)
Most recalls cover only certain model years, serials or build dates — view each notice to check it against your own unit.
Sources
- Archived document
Source: clubcar.com/en-us/personal/golf-carts/onward-2-passenger/specifications
Retrieved September 14, 2026
- Archived document
Source: assets-us-01.kc-usercontent.com/6abcfde7-3568-006f-9221-66adacb7173a/eac22fc4-0ac4-4345-a94d-a34553cd30a4/onward-li-ion-sell-sheet.pdf
Retrieved September 15, 2026
- Archived document
Source: clubcar.com/en-us/lithium-ion
Retrieved September 15, 2026
- 2023 Club Car Onward | Bent Wrench CartsArchived document
Source: inventory.bentwrenchcarts.com/listing/used-2023-hp-fla-club-car-onward-linwood-north-carolina-12166
Retrieved October 8, 2026
- Club Car Recalls Gas Golf and Transport Vehicles Due to Fire and Burn Hazards (Recall Alert) | CPSC.govArchived document
Source: cpsc.gov/Recalls/2019/Club-Car-Recalls-Gas-Golf-and-Transport-Vehicles-Due-to-Fire-and-Burn-Hazards-Recall-Alert
Retrieved October 11, 2026