E-Z-GO Express S4 (2024)

E-Z-GO's own address for this model was at ezgo.txtsv.com/personal/models/past-models/MY24-express-s4. E-Z-GO keep this model under Past Models rather than in the current line-up; the address answers and shows the vehicle, titled by its 2024 model year. Checked 15 September 2026.

The E-Z-GO Express S4 is a golf cart with a 56.7 V pack, a load capacity of 800 lb (363 kg) and a curb weight of 965 lb (437 kg).

Last updated: 28 October 2026

What we found

A battery is documented for it: ELiTE Lithium (Core-56.7V Max), identified by the manufacturer as the correct match.
Batteries are documented for it, from the manufacturer's own documentation.
Further batteries are listed on this model's battery page and are not included in the count above.
A battery is explicitly documented as NOT fitting it: 38V 105Ah Cube LiFePO4 Gen3.
Specifications are published for it, each with its source.
11 figures are contradicted by another credible source. Both readings are shown below, and neither is presented as the correct one.

What else the Express S4 needs

Parts a source says are needed beyond the battery itself. Reported, not recommended — read the source beside each one and confirm it with the manufacturer before buying anything.

UnconfirmedWhatever pack is fitted
An OEM-approved lithium-ion charger for this vehicle — one the battery's management system can work with. E-Z-GO's manual gives three charge rates chosen by battery temperature (none below 14°F or above 140°F, a six-amp pre-charge at the edges, full charging in between) and says the BMS and the charger cooperate to pick one. A charger that cannot be told the pack's temperature cannot do that. The manual documents Delta-Q QuiQ models 913-4830-E3/E38/E5/E58, an RC900 ELiTE and an E-Z-GO ELiTE charger in its appendices.
“Use only the OEM approved Lithium-Ion battery charger for your vehicle”
Source: ezgo.txtsv.com/sites/default/files/_media/content/pdfs/OwnersManuals/Express_S2_S4_EliteLithium_Manual.pdf

Motor and performance

Turning radius: 11.4 ft (3.5 m)
Rear axle ratio: 16.99:1 (Forward)
Motor type: Sources disagree
Motor power rating: Sources disagree
Top speed: Sources disagree
Drivetrain: Motor Shaft Direct Drive
Transaxle: Clutch type limited-slip differential with helical gears
Gear selection: Dash Mounted FNR/key switch
Key or pedal start: Pedal
Controller current: 235 Amp
Speed controller rating: 235 A, AC

Battery and charging

Battery fitted: Single, 56.7 Vol Li-Ion Composite Module (Standard Configuration)
Starter battery (gas models): 12-Volt Maintenance-Free (525 CCA, 85 minute reserve)
Lithium trim, where the maker offers one: One 56.7-volt lithium module
Charger fitted to the lithium trim: A 56.7 V, 350 W charger with a 3 m cord
Permitted charger: Only the OEM lithium charger
Electrical system: 48 V primary with a 12 V auxiliary
Voltage window it works between: 39.2-56.7V Li-Ion Battery
Charger fitted: 56.7V 350W Domestic Charger, 3m charging cord
Battery: 56.7 V

Battery care and safety

Temperatures it must not be charged at: No charging below 14°F or above 140°F; reduced rate at the edges
Temperatures it charges at a reduced rate: 6 A pre-charge: 14-41°F and 104-140°F
Temperatures it charges at full rate: Full charging: 37.4-107.6°F (3-42°C)

Size and fit

Ground clearance: 7.3 in (18.5 cm)
Overall length: Sources disagree
Tyre size fitted: Paramount M/T 23x10-14
Curb weight: 965 lb (437 kg)
Seating capacity: 4-Person
Body panel material: Injection Molded TPO
Overall width: Sources disagree
Height without the canopy: 52.0 in (132 cm)
Height with the canopy: 81.9 in (208 cm)
Front wheel track: 37.9 in (96.3 cm)
Rear wheel track: 39.2 in (99.6 cm)
Outside clearance circle: 22.8 ft (7.0 m)
Dash storage: 1123 in³ (18403 cm³)
Dry weight, without batteries: 918 lb (416 kg)
Load capacity: 800 lb (363 kg)
Wheelbase: Sources disagree
Frame material: Welded Steel with E-Coat & DuraShield™ Powder Coat

Brakes and safety

Parking brake: Automatic Electromagnetic
Brakes: Sources disagree

Frame and components

Steering: Sources disagree
Front suspension: Leaf springs with hydraulic shock absorbers
Frame construction: Welded steel with DuraShieldTM powder coat and e-coat
Suspension: Leaf Springs with Hydraulic Shock Absorbers
Rear suspension: Leaf springs with hydraulic shock absorbers

Where you can drive it

Federal motor vehicle safety standards: E-Z-GO say it does not meet the federal standards for road use
Converting it into a low-speed vehicle: E-Z-GO will not approve a conversion to a low-speed vehicle

Recalls and fire safety

What recall 24713 actually names: Recall 24713 names the ELiTE Express S6 and L6, not this model
Hazard the regulator describes: Sources disagree
Remedy the regulator gives: Sources disagree
Units the recall covers: Sources disagree

Chargers

Named by the manufacturer for the Express S4. Reported, not endorsed — confirm with the manufacturer before charging anything.

The manufacturer names 3 for this model and does not say which one a particular machine left the factory with. Read the part number off the label on your own unit.

Delta-Q Technologies QuiQ 1 kW Industrial Battery Charger (E-Z-GO)UnconfirmedView charger: Delta-Q Technologies QuiQ 1 kW Industrial Battery Charger (E-Z-GO) →
“Charge only 48 Volt Lithium-Ion type batteries activated by Samsung SDI. Other types of batteries may burst causing personal injury and damage.”
Source: ezgo.txtsv.com/sites/default/files/_media/content/pdfs/OwnersManuals/Express_S2_S4_EliteLithium_Manual.pdf
Delta-Q Technologies RC900 ELiTE Onboard ChargerUnconfirmedView charger: Delta-Q Technologies RC900 ELiTE Onboard Charger →
“for use with E-Z-GO ELiTE lithium brand vehicles (Model 673928)”
Source: ezgo.txtsv.com/sites/default/files/_media/content/pdfs/OwnersManuals/Express_S2_S4_EliteLithium_Manual.pdf
Delta-Q Technologies ELiTE Charger (E-Z-GO)UnconfirmedView charger: Delta-Q Technologies ELiTE Charger (E-Z-GO) →
“for use with E-Z-GO ELiTE lithium brand vehicles”
Source: ezgo.txtsv.com/sites/default/files/_media/content/pdfs/OwnersManuals/Express_S2_S4_EliteLithium_Manual.pdf

This model’s recall history

Notices that name this model in other model years. They are not recalls for the machine on this page — each one says below which years it covers.

CPSC 21783 — September 16, 2021

Textron Specialized Vehicles Recalls PTV and Off-Road Vehicles Due to Crash Hazard (Recall Alert)View recall →

This notice covers TXT-chassis vehicles manufactured between 1 March and 10 June 2021, and names the Express S2 and S4 among them. This row is a model year 2024 machine and is outside that window.

Battery specs & replacement options

Identified power-system parts

Navitas Vehicle Systems states: “E-Z-GO S4 / L6”

Sources

Archived document
Source: ezgo.txtsv.com/sites/default/files/2023-05/CON-0423_ExpressS4_SS_82297-G20_DIGITAL.pdf
Retrieved October 13, 2026
Archived document
Source: ezgo.txtsv.com/sites/default/files/_media/content/pdfs/OwnersManuals/Express_S2_S4_EliteLithium_Manual.pdf
Retrieved September 15, 2026
Textron Specialized Vehicles Recalls E-Z-GO PTV And Tracker OX EV Vehicles Due to Crash Hazard (Recall Alert) | CPSC.govArchived document
Source: cpsc.gov/Recalls/2024/Textron-Specialized-Vehicles-Recalls-E-Z-GO-PTV-And-Tracker-OX-EV-Vehicles-Due-to-Crash-Hazard-Recall-Alert
Retrieved September 16, 2026
Textron Specialized Vehicles Recalls E-Z-GO PTVs Due to Fire Hazard (Recall Alert) | CPSC.govArchived document
Source: cpsc.gov/Recalls/2023/Textron-Specialized-Vehicles-Recalls-E-Z-GO-PTVs-Due-to-Fire-Hazard-Recall-Alert
Retrieved October 10, 2026
Transport Canada Recall - 2022609 - TEXTRON - Canada.caArchived document
Source: recalls-rappels.canada.ca/en/alert-recall/transport-canada-recall-2022609-textron
Retrieved October 11, 2026
Archived document
Source: ezgo.txtsv.com/sites/default/files/_media/content/pdfs/OwnersManuals/Express_S4_Manual.pdf
Retrieved September 27, 2026