Allied 48V 36Ah Drop-In-Ready

dir.alliedlithium.com/products/allied-lithium-48v-x-30ah-batteries

The Allied 48V 36Ah Drop-In-Ready is a battery pack with a nominal voltage of 51.2 V, a continuous discharge of 30 A, a peak of 60 A for 10 s and a weight of 40 lb.

Last updated: 29 September 2026

What we found

Documented by its manufacturer to fit the carts listed below across several brands.
Specifications are published for it, each with its source.
1 figure is contradicted by another credible source. Both readings are shown below, and neither is presented as the correct one.

Battery and charging

Round-trip efficiency: 99 %
Minutes it runs at a 25 A draw: 86 minutes at 25 A
Module connection: In parallel — unlike the series pack they replace
How it is sold: Sold as two to eight modules, 72Ah to 288Ah
Case material: steel
Nominal capacity: 36 Ah
Nominal voltage: 51.2 V
Cell chemistry: cylindrical LiFePO4 cells
Continuous discharge: 30 A
Peak discharge: 60 A for 10 s
Recommended charge voltage: 40–59.2 V, as printed
Recommended charge current: 7.5–30 A
Discharge cut-off: 32 V (2.0 ± 0.08 V per cell)
Charge cut-off: 62.4 V (3.9 ± 0.05 V per cell)
Low-voltage disconnect: 40 V (2.5 V per cell)
Maximum in parallel: 6 to 8
Stated energy: 1,728 Wh, as printed

Battery care and safety

Self-discharge rate: 3–5 % per month
Where the BMS cuts out on current: ≤105 A ±2 A, within ≤1 s
Voltage it reconnects at after a low cut-out: 36.8 V (2.3 ± 0.1 V per cell)
Voltage charging resumes at: 61.6 V, printed with 3.55 V per cell
What to leave it charged to in cold storage: not below 30 % state of charge
Short-circuit protection: 200–500 ms
Charge temperature range: 32 °F to 131 °F
Discharge temperature range: 15 °F to 140 °F
Shipping classification: UN 3480, Class 9
Temperatures at which protection releases: releases at 23 °F (low) and 122 °F (high)
Charge level in transit or on delivery: about 50 % on delivery

Size and fit

Overall dimensions: 10.2 × 7 × 9.75 in (L × W × H)
Stated weight: 40 lb
Terminal type: M8
Terminal material: brass

Compatibility

Listed carts: Eight Club Car models, the Onward among them
What paralleling packs does to capacity: parallel adds amp-hours

Frame and components

Enclosure rating: IP67

Identity

Name on the maker's own page: ALLIED 48V 36AH LIFEPO4 LITHIUM GOLF CART BATTERIES - "DROP-IN-READY"
The pack the maker says this one replaced: The 48V 30Ah drop-in — 20% more capacity in the same footprint

Conditions and exclusions

What voids battery cover: An Allied charger AND an Allied cutoff switch, or cover is void

Other findings

Bluetooth: yes
Cart voltage naming by maker: how Allied write cart voltages
Charger compatibility stated by maker: an Allied lithium charger
Manufacturer denies series connection: never in series

Certification claims

Datasheet certification claim: cells: UL 1642, 'IEC62633'; battery: CE, UN 38.3 — claimed, not certificates

Compatible chargers

48V Waterproof Lithium Battery Charger58.4V output15AUniversal Snap, Yamaha, EZGO or Club Car harness — chosen per cartUnconfirmedView charger: 48V Waterproof Lithium Battery Charger →
Allied on their own charger: "Designed to work perfectly with 48V Allied lithium batteries". They name their 48V range rather than this pack, and do not say whether the charger the cart arrived with will charge it.

Compatible carts

Only the 48-volt Onward — Allied list the model by voltage and not by passenger count — check yours before buying. — applies to Club Car Onward 2 Passenger, Club Car Onward 4 Passenger, Club Car Onward 6 Passenger

Sources do not establish: how many modules this cart needs, and whether they fit its battery bay. Allied sell this pack in sets of two to eight and tell the buyer to check a sizing chart, which is not on the page naming the cart. Club Car publish no compartment dimensions this catalogue holds.

Applies to Club Car DS, Club Car Tempo

Sources do not establish: how many modules this cart needs, and whether they fit the battery bay. Allied sell the pack in sets of two to eight and say to check a sizing chart, which is not published on the page; Club Car publish no battery-tray dimensions for any Onward. Measure the bay and confirm the set size with the seller before buying.

Applies to Club Car Onward 2 Passenger, Club Car Onward 4 Passenger, Club Car Onward 6 Passenger

Sources do not establish: how many modules this cart needs, and whether they fit its battery bay. Allied sell this pack in sets of two to eight and point at a sizing chart that is not on the page naming the cart. Yamaha publish no compartment dimensions this catalogue holds.

Applies to Yamaha Golf Car Adventurer One, Yamaha Golf Car Drive, Yamaha Golf Car Drive 2, Yamaha Golf Car G22E G-MAX

Source: alliedlithium.com/pages/club-car-golf-cart-lithium-batteries-models

Source: alliedlithium.com/pages/yamaha-golf-cart-lithium-batteries-models

Club Car DSManufacturer documentedView cart: Club Car DS →View battery: Club Car DS →
Only a DS built from 2000 onwards, which Allied list as "DS2000+ (48V)". A DS built BEFORE 2000 is 36 volts on Allied's own list — "Pre2000 (36V)" — and this 48-volt pack is not an answer for it. Check yours before buying.
Club Car Onward 2 PassengerManufacturer documentedView cart: Club Car Onward 2 Passenger →View battery: Club Car Onward 2 Passenger →
Club Car Onward 4 PassengerManufacturer documentedView cart: Club Car Onward 4 Passenger →View battery: Club Car Onward 4 Passenger →
Club Car Onward 6 PassengerManufacturer documentedView cart: Club Car Onward 6 Passenger →View battery: Club Car Onward 6 Passenger →
Club Car PrecedentManufacturer documentedView cart: Club Car Precedent →View battery: Club Car Precedent →
Only the 48-volt Precedent — Allied list the model by voltage, and not by year or trim — check yours before buying.
Sources do not establish: how many modules a Precedent needs, and whether they fit its battery bay. Allied sell this pack in sets of two to eight and tell the buyer to check a sizing chart, which is not on the page naming the cart. Club Car publish no compartment dimensions this catalogue holds — their Precedent Owner's Manual is sold rather than published, and only its two-page preview is held.
Club Car TempoManufacturer documentedView cart: Club Car Tempo →View battery: Club Car Tempo →
Only the 48-volt Tempo — Allied list the model by voltage, and attach no year — check yours before buying.
Yamaha Golf Car Adventurer OneManufacturer documentedView cart: Yamaha Golf Car Adventurer One →View battery: Yamaha Golf Car Adventurer One →
Only the 48-volt Adventurer, Yamaha's utility line — Allied list it at 48V with no year — check yours before buying.
Yamaha Golf Car Adventurer TwoUnconfirmedView cart: Yamaha Golf Car Adventurer Two →View battery: Yamaha Golf Car Adventurer Two →
Only the 48-volt electric Adventurer Two — Allied list "Adventurer (48V)" with no year and no generation, the same entry already attached to the Adventurer One — check yours before buying.
Sources do not establish: how many modules this cart needs, and whether they fit its battery bay. Allied sell this pack in sets of two to eight and point at a sizing chart that is not on the page naming the cart. Yamaha publish no compartment dimensions. Also not established: whether Allied mean the One, the Two, or both — their page draws no distinction between Yamaha's two Adventurer generations.
Yamaha Golf Car DriveManufacturer documentedView cart: Yamaha Golf Car Drive →View battery: Yamaha Golf Car Drive →
Only the 48-volt Drive — Allied list "Drive & Drive 2 (48V)" and give no year — check yours before buying.
Yamaha Golf Car Drive 2Manufacturer documentedView cart: Yamaha Golf Car Drive 2 →View battery: Yamaha Golf Car Drive 2 →
Only the 48-volt Drive 2 — Allied list "Drive & Drive 2 (48V)" and give no year — check yours before buying.
Yamaha Golf Car G22E G-MAXManufacturer documentedView cart: Yamaha Golf Car G22E G-MAX →View battery: Yamaha Golf Car G22E G-MAX →
Only the 48-volt G22, which Allied write as "G22 / GMAX" — the generation ABOVE their 36-volt G14-G19 range, and the boundary is the point — check yours before buying.

Sources

Allied Battery — Allied Lithium batteries for Yamaha Golf CartsManufacturer battery page
Allied Battery
Source: alliedlithium.com/pages/yamaha-golf-cart-lithium-batteries-models
Retrieved September 15, 2026
Allied Battery — Allied Lithium Batteries for Club Car Golf CartsManufacturer battery page
Allied Battery
Source: alliedlithium.com/pages/club-car-golf-cart-lithium-batteries-models
Retrieved September 14, 2026
Allied Battery — 48V Waterproof Lithium Battery ChargerManufacturer battery page
Allied Battery
Source: alliedlithium.com/collections/chargers/products/allied-lithium-onboard-waterproof-battery-charger-48v-15amp
Retrieved September 14, 2026
Allied Battery — Allied 48V Lithium Batteries for EZGO RXVManufacturer battery page
Allied Battery
Source: alliedlithium.com/pages/ezgo-rxv-battery-installation
Retrieved September 14, 2026
More Runtime. Same Footprint: The New Allied 48V 36AH Drop-In-Ready Ba - Allied Lithium Golf Cart BatteriesManufacturer document
Allied Battery
Source: alliedlithium.com/blogs/news/more-runtime-same-footprint-the-new-allied-48v-36ah-drop-in-ready-battery
Retrieved September 15, 2026
Archived document
Source: cdn.shopify.com/s/files/1/0643/5677/8175/files/Data_Sheet_48V_36AH_-_2-24-26.pdf
Retrieved September 29, 2026
Archived document
Source: cdn.shopify.com/s/files/1/0643/5677/8175/files/Quickstart_Guide_-_Drop-In-Ready_2-25-26.pdf
Retrieved September 29, 2026
Archived document
Source: dir.alliedlithium.com/products/allied-lithium-48v-x-30ah-batteries
Retrieved September 14, 2026
Allied Battery Warranty - The Best Lithium Golf Cart Batteries - Drop in ReadyArchived document
Source: dir.alliedlithium.com/pages/allied-battery-warranty
Retrieved September 15, 2026